Incidence of Mycotoxin Contamination along the Maize Value Chain in Lusaka Province of Zambia
Author(s)
Mweshi Mukanga , Mathias Tembo , Mable Mudenda ,
Download Full PDF Pages: 69-77 | Views: 739 | Downloads: 205 | DOI: 10.5281/zenodo.3484487
Abstract
Aflatoxins and Fumonisins are carcinogenic mycotoxins produced by Aspergillus spp. and Fusarium spp., respectively
that frequently contaminate maize and its derivative products when the conditions are ideal. A survey was conducted to establish levels of aflatoxin and fumonisins contamination in maize and maize products in Lusaka Province of Zambia. Sixty-six maize samples comprising grain, samp, maize flour, and popcorn were collected from farms, markets, street vendor and hammer mills. Total fungal forming units were estimated after plating on selective media. and incubating up to 14 days. Quantification of total aflatoxin and fumonisins was done using enzyme-linked immunosorbent assay. The maize grain sourced from farm stores in Lusaka had highest mean number of fungal colonies, 4.18 ± 0.05 log CFU/g while the breakfast maize mealie meal flour from the supermarkets had lowest number, 1.31 ± 0.11 log CFU/g. All the maize products, tested positive for aflatoxin and fumonisins with 54.6% above the Zambian regulatory standard of 10 μg kg-1 for total aflatoxin, while all the samples were significantly higher than the acceptable level of PMTDI of fumonisins, 2 mg kg-1. Significantly higher amounts of aflatoxins were obtained from hammer mill, 11.28 μg kg-1 while the least was in the maize products sold by street vendors, 2.62 μg kg-1. The highest amount of fumonisins was recorded in the maize grain obtained from the farms, 2991 mg kg-1 followed by those from the hammer mill, 1659 mg kg-1. Both aflatoxin and fumonisins were found to coexist in all the maize products analyzed. The high levels of contamination observed in the maize products suggest that both the urban and peri-urban population in Lusaka province were being exposed to high levels of both aflatoxin and fumonisins. However, the high level of fumonisins observed in the maize products merits further investigation
Keywords
aflatoxins, fumonisins, contamination, maize products, Lusaka
References
i. Abbas, H.K., Cartwright, R.D., Xie, W.P. & Shier, W.T. (2006). Aflatoxin and fumonisin contamination of corn (maize, Zea mays) hybrids in Arkansas. Crop. Prot., 25: 1-9
ii. Antonissen, G., Martel, A., Pasmans, F., Ducatelle, R., Verbrugghe, E., Vandenbroucke, V., Li, S., Haesebrouck, F., Van Immerseel, F. & Croubels S. (2014). The Impact of Fusarium Mycotoxins on Human and Animal Host Susceptibility to Infectious Diseases. Toxins 2014, 6, 430-452; doi:10.3390/toxins6020430
iii. Bigirwa, G., Kaaya, A.N., Sseruwu, G., Adipala, E. & Okanya, S. (2007). Incidence and Severity of Maize Ear Rots and Factors Responsible for Their Occurrence in Uganda. Journal of Applied Sciences 7:3780-3785.
iv. Bruns, H.A. (2003). Controlling aflatoxin and fumonisin in maize by crop management. Journal of Toxicology, Toxin Rev., 22: 153-173.
v. CAST (2003). Mycotoxins: Risk in plant animal and human system. Task force Report No 139.
vi. Clarke, R. & Fattori V. (2013). Codex standards: A global tool for aflatoxins management. In: Unnevehr L., Grace D. (eds.). Aflatoxins: Finding solutions for improved food safety. Vision 2020 for food, agriculture and environment. Agriculture for Nutrition and Health Program of CGIAR. International Food and Policy Research Institute, IFPRI, Washington DC.
vii. Darwish, W.S., Ikenakai, Y., Nakayama, S.M.M. & Ishizuka, M. 2014. An Overview on Mycotoxin Contamination of Foods in Africa. J. Vet. Med. Sci. 76: 789–797.
viii. FAO/WHO (2016) 83rd Joint FAO/WHO Expert Committee on Food Additives (JECFA83/SC) Eighty-third meeting Summary and conclusions. Rome, Italy. 16p
ix. Guo, B.Z., Ji, X., Ni, X., Fountain, J.C., Li, H., Abbas, K.H., Lee, R.D. & Scully, B.T. (2017). Evaluation of maize inbred lines for resistance to pre-harvest aflatoxin and fumonisins contamination in the field. Crop Journal, 5: 259-264
x. Hell, K., Cardwell, K. & Poehling, H. (2003). Relationship between management practices, fungal infection and aflatoxin for stored maize in Benin. J. Phytopath., 151: 690-698.
xi. Hell, K. & Mutegi, C. (2011). Aflatoxins control and prevention strategies in key crops of Sub-Saharan Africa. African Journal of Microbiology Research 5: 456–466.
xii. ICRISAT. (2016). How to Reduce Aflatoxin Contamination in Groundnuts and Maize. A Guide for Extension Workers. Patancheru 502 324, Telangana, India: International Crops Research Institute for the Semi-Arid Tropics. 24 pp.
xiii. Kachapulula, P.W., Akello, J., Bandyopadhyay, R. &, Cotty, P.J. (2017). Aflatoxin contamination of groundnut and maize in Zambia: observed and potential concentrations. Journal of Applied Microbiology 122, 1471–1482
xiv. Kankolongo, M.A., Hell, K. & Nawa, I.N. (2009). Assessment for fungal mycotoxin and insect spoilage in maize stored for human consumption in Zambia. Journal of Science of Food and Agriculture 89: 1366–75
xv. Kedera, C.J., Platter, R.D. & Desjardins, A.E. (1999). Incidence of Fusarium spp. and levels of fumonisins B1 in maize in Western Kenya. Applied and Environmental Microbiology 65:41-44.
xvi. Kimanya, M.E. (2015). The health impacts of mycotoxins in the eastern Africa region. Current opinion in Food Science 6:7–11
xvii. Lanubile, A., Maschietto V, Borelli VM, Stagnati L, Logrieco, A.F. & Marocco, A. (2017). Molecular basis of resistance to fusarium ear rot in maize. Frontiers in Plant Science 8: 1774.
xviii. Leslie, J.F. & Summerell, B.A. (2006). The Fusarium Laboratory Manual. Blackwell Publishing, Hoboken, 1-2.
xix. Lewis, L., M. Onsongo, H. Njapau, H. Schurz-Rogers, G. Luber, S. Kieszak, J. Nyamongo, L. Backer, A. Mohamud Dahiye, A. Misore, K. DeCock, C. Rubin, & the Kenya Aflatoxicosis Investigation Group (2005). Aflatoxin Contamination of Commercial Maize Products during an Outbreak of Acute Aflatoxicosis in Eastern and Central Kenya. Environmental Health Perspectives 113.: 1763–1767
xx. Marín, S., Sanchis, V., Ramos, A.J., Vinas, I. & Magan N. (1998). Environmental factors, in vitro interactions, and niche overlap between Fusarium moniliforme, F. proliferatum, and F. graminearum, Aspergillus and Penicillium species from maize grain. Mycol. Res., 102: 831-837
xxi. Misihairabgwi, J.M., Ezekiel, C.N., Sulyok, M., Shepard, G.S. & Krska, R. (2017). Mycotoxin contamination of foods in Southern Africa: A 10-year review (2007–2016). Critical Reviews in Food Science and Nutrition https://doi.org/10.1080/10408398.2017.1357003
xxii. Mukanga M, J. Derera J, P. Tongoona, P. & Laing, M.D. (2010). A survey of pre-harvest ear rot diseases of maize and associated mycotoxins in South and Central Zambia. International Journal of Food Microbiology141: 213–21
xxiii. Munkvold, G.P. (2003). Cultural and Genetic Approaches to Managing Mycotoxins in Maize. Annual Review of Phytopathology 41:99-116
xxiv. Mutiga, S.K., Hoffmann., Harvey, J.W., Milgroom, M.G. & Nelson, R.J. (2015). Assessment of aflatoxin and fumonisin contamination of maize in Western Kenya. Phytopathology 105(9):1250-1261
xxv. Nelson, P.E., Tousson, T.A. & Marasas WFO, 1983. Fusarium species: an illustrated manual for identification. Penn State Univ. Press. University Park, PA, USA. 193 pp.
xxvi. Nyangi, C.J. 2014. Aflatoxin and fumonisin contamination of maize and beans along the food and feed value chain in Babti district, Tanzai. Sokoine University, Morogoro M.Sc. Thesis 110pp
xxvii. Park, J., Kim, D. H., Moon, J. Y., An, J. A., Kim, Y. W., Chung, S. H., & Lee, C. (2018). Distribution Analysis of Twelve Mycotoxins in Corn and Corn-Derived Products by LC-MS/MS to Evaluate the Carry-Over Ratio during Wet-Milling. Toxins 10(8), 319. doi:10.3390/toxins10080319
xxviii. Pitt, J.I. & Hocking, A.D. (1997). Fungi and Food Spoilage, Cambridge: Chapman & Hall, 2nd edition
xxix. Probst, C., Schulthess, F. & Cotty, P.J. (2010). Impact of Aspergillus section Flavi community structure on the development of lethal levels of aflatoxins in Kenyan maize (Zea mays). J Appl Microbiol 108, 600–610.
xxx. Rheeder, J.P., Marasas, W.F.O., Thiel, P.G., Sydenham, E.W. Shephard, G. & Schalkwyk, D.J. van (1992). Fusarium moniliforme and fumonisins in corn in relation to human oesophageal cancer in Transkei. Phytopathology 1992, 82, 353–357.
xxxi. Robertson-Hoyt, L.A., J. Betrán, G. A. Payne, D. G. White, T. Isakeit, C. M. Maragos, T. L. Molnár, & Holland, J.B. (2007). Relationships Among Resistances to Fusarium and Aspergillus Ear Rots and Contamination by Fumonisin and Aflatoxin in Maize. Phytopathology 97: 311-317. https://doi.org/10.1094/PHYTO-97-3-0311
xxxii. Udomkun, P., Wiredu, A., Nagle, M., Bandyopadhyay, R., Müller, J. & Vanlauwe, B. (2017). Mycotoxins in Sub-Saharan Africa: Present situation, socio-economic impact, awareness, and outlook: Food Control 72:110-122
xxxiii. Wanjiku, G.G. (2015). Post-harvest fungi diversity and level of aflatoxin contamination in stored maize: Cases of Kitui, Nakuru and Transnzoia Counties in Kenya. Kenyatta University. MSc Thesis
xxxiv. Williams, J.H., Phillips, T.D., Jolly, P.E., Stiles, S.K., Jolly, C.M. & Aggarwal, D. (2004). Human aflatoxicosis in developing countries: a review of toxicology, exposure, potential health consequences, and interventions. Am J Clin Nutr. 80, 1106–1122.
xxxv. Wu, F., Stacy, S. L. & Kensler, T.W. (2013). Global Risk Assessment of Aflatoxins in Maize and Peanuts: Are Regulatory Standards Adequately Protective? Toxicological Sciences. 135:251-259. doi:10.1093/toxsci/kft132.
xxxvi. Pitt, J.I.; Hocking, A.D., & Glenn, D.R. (1983). An improved medium for the detection of Aspergillus flavus and Aspergillus parasiticus. J. Appl. Bacteriol., 54, 109-114, 1983.
Cite this Article: